FULL INTEGRATED BATTERY (500 & 625 Wh)

Full Integrated Battery.

Thanks to our complete battery integration technology, the new frames are lighter and the batteries are more protected. From the standard models to the PowerTube, the batteries of all types practically disappear in the frame giving our e-bikes a great appearance, which combines sportiness and elegance. The sealed battery covers protect them from the penetration of impurities and water and can be easily detached for recharging. In addition, all pedal assist models are supplied as standard with the charging system directly on the frame.

Semi-integrated battery:

Thanks to this special construction method, we were able to mount the battery by partially integrating it into the down tube, in order to keep it well protected from mechanical damage caused by the projection of stones and other impacts. We positioned the added weight from the battery and from the motor unit more in the center, towards the bottom bracket, to obtain an extremely low center of gravity. The result? An extremely easy to handle bike on the trails, capable of offering a relaxed and natural ride, with which you will even forget the presence of the engine.

OPTIMIZED AUTONOMY

By following these tips, you increase the autonomy of the batteries:

TIRE PRESSURE
Rolling resistance can be minimized if the tires have adequate pressure. It is therefore advisable to inflate them to the maximum allowable pressure in order to maximize autonomy.

RECHARGEABLE BATTERY & TEMPERATURE
As the temperature drops, the efficiency of the rechargeable batteries drops, due to the increase in electrical resistance. Consequently, in winter it is necessary to provide for a reduction in the usual autonomy.

CADENCE
A cadence greater than 50 revolutions per minute optimizes the efficiency of the motor unit. On the other hand, an extremely slow pedaling rhythm is highly energy-consuming.

STARTING & BRAKING
As in cars, frequent stops and restarts are less economical than walking at almost constant speed over long distances.

REPORT CHANGE
Even changing gear correctly makes e-bikes more efficient. For example, a low ratio should be used for starts and slopes, then increased according to the terrain and speed.

Power Pack 500
Power Pack 625

BATTERY CARE

CHARGING
Recharge the battery in dry places and at room temperature.

WINTERING
Dry the batteries and keep them at temperatures between 0 and 20 ° C. If the battery is completely discharged or fully charged it means more stress. The ideal charge level for long-term storage is between 30 – 60%.

HOUSING
Avoid temperatures above 60 ° and below -10 ° C.

TRANSPORT
For safe transportation, for example in a car, always remove the battery from the e

CLEANING &D MAINTENANCE
Avoid direct water jet washing, especially with high-pressure washers. Occasionally clean and lightly lubricate the connector poles.

WINTER USE
In winter we recommend installing the battery shortly before departure. For long journeys in cold temperatures, the use of thermal covers is recommended.

REVISION
Through the diagnostic tool, Intersport Val Gardena can check the health of the battery.

RECHARGING TIME

The charging time depends on the capacity of the battery and the charger: with the standard charger the PowerPack 500 takes two hours for a half charge. Full charging of a PowerPack 500 takes 4.5 hours. With the 6A charger (super fast) a full charge for a 500Wh battery lasts only 3 hours!

Tempo di ricarica batteria

FATTORI POSITIVI

• Low load
• Storage at a temperature between 0 and 20 °C
• Storage at approx. 30 to 60% charge statuscycles

FATTORI NEGATIVI

• Heavy-duty use
• Storage at over 30 °C ambient temperature
• Prolonged storage in a completely charged or completely discharged state
• Parking of the eBike in the blazing sun

[fusion_products_slider picture_size=”fixed” cat_slug=”bici-elettriche-nuove” number_posts=”5″ carousel_layout=”title_below_image” autoplay=”no” columns=”4″ column_spacing=”7″ scroll_items=”” show_nav=”yes” mouse_scroll=”no” show_cats=”no” show_price=”yes” show_buttons=”yes” hide_on_mobile=”small-visibility,medium-visibility,large-visibility” class=”” id=”” /]